Download or read book Criteria and Benefits of Penetrating Sealants for Concrete Bridge Decks written by Upul Attanayaka and published by . This book was released on 2002 with total page 82 pages. Available in PDF, EPUB and Kindle. Book excerpt: This report evaluates the potential durability gained by the use of penetrating sealants on concrete bridge decks. The factors affecting the depth of penetration are identified through a fundamental approach and the literature on penetrating sealants, concrete deterioration, concrete durability, and concrete permeability. Properties and the use of silane, siloxane, and high molecular weight methacrylate sealers are discussed.
Download or read book Bridge Deck Concrete Sealers written by John D. Wenzlick and published by . This book was released on 2007 with total page 17 pages. Available in PDF, EPUB and Kindle. Book excerpt: In the last several years, MoDOT has experienced problems with excessive amounts of cracking on some new concrete bridge decks. This has led to various concrete sealers being used for sealing cracks as well as whole decks, instead of applying linseed oil. Linseed oil is the only concrete sealer listed in Missouri's Standard Specifications, and is used for resistance to scaling on new bridge decks. Secondly, some recent projects re-texturing decks built with dense concrete overlays have specified penetrating concrete sealers. The concern was if linseed oil was used on the diamond ground surface, it might not have good frictional properties. Either extra linseed oil might be left on the surface or the linseed oil might not cure quickly enough to switch traffic onto it after short lane closures. It was decided that new penetrating sealers be used in these situations by special provision to the contract. Four types of penetrating sealers were tested against linseed oil in the laboratory to rate their effectiveness, pick criteria for testing needed in accepting sealers and write a new specification to best protect concrete bridge decks from deterioration. In the case of new concrete decks it is recognized by American Concrete Institute that cracks smaller than 0.18 mm do not let chloride ions from salt penetrate through them. It was concluded that if there are very few cracks bigger than this, those cracks do not need to be sealed, and linseed oil can be used to help prevent scaling. If cracks were bigger than this it would be better to forego the linseed oil treatment and use a crack sealer. A table with concrete sealers classified into three performance groups is presented with the sealers ranked by performance and including cost per ft. 2. It was found from this study that penetrating sealers are not good at sealing large cracks. Although an Ohio DOT test was used in this study to measure crack sealing capabilities, it did not give consistent answers. It did help identify what size cracks need to be sealed by a better crack sealer, such as a two-part epoxy. It was found that cracks in the range of 0.30 mm to 0.64 mm start to allow a saline solution to leak through the concrete very swiftly. So even if a penetrating sealer is used on a deck with many cracks, those 0.64 mm cracks and bigger need a more appropriate crack filler/sealer to seal the individual big cracks first. Sealing cracks on existing older decks should be done using less expensive products that seal the entire small and medium-sized cracks and are effective for 2-4 years. A table listing these crack sealers is also presented. As a result of testing in this study one of these products was approved for preventive maintenance use statewide.
Download or read book Field Performance of Penetrating Sealers for Concrete Bridge Decks written by Mark G. Hagen and published by . This book was released on 1995 with total page 25 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Effectiveness and Relative Performance of Concrete Bridge Deck and Crack Sealants written by Melissa A. Dorshorst and published by . This book was released on 2005 with total page 374 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Evaluation of Concrete Deck and Crack Sealers written by José Antonio Pincheira and published by . This book was released on 2005 with total page 166 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Sealers for Portland Cement Concrete Highway Facilities written by Philip Dale Cady and published by . This book was released on 1994 with total page 100 pages. Available in PDF, EPUB and Kindle. Book excerpt: This synthesis document will be of interest to materials, maintenance, and bridge engineers, and others responsible for protecting and maintaining portland cement concrete (PCC) roadway surfaces. It will be of special interest to materials research and testing officials, as well as to manufacturers who are concerned with developing and evaluating sealers for PCC highway facilities. The information in this Synthesis is limited to surface-applied liquid sealers that are primarily intended to retard the transmission of water and ions below the roadway surface. This report of the Transportation Research Board provides detailed information on generic concrete sealing materials that may be considered a primer on the topic, describing the various classes of sealers, their chemical characteristics, application to specific needs, and practice and performance characteristics. In addition, information is provided on evaluation and testing, application and costs, and the safety and environmental issues of concern with their use. Also included is a glossary of terms, extensive references, and an appendix that includes materials on a procedure for the estimation of service life and a model sealer specification.
Download or read book Penetrating Sealers for Protecting Concrete Bridge Decks Against Chloride Intrusion written by Robert G. Tracy and published by . This book was released on 1979 with total page 48 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Development and Layout of a Protocol for the Field Performance of Concrete Deck and Crack Sealants written by José Antonio Pincheira and published by . This book was released on 2009 with total page 62 pages. Available in PDF, EPUB and Kindle. Book excerpt: The main objective of this project was to develop and layout a protocol for the long-term monitoring and assessment of the performance of concrete deck and crack sealants in the field. To accomplish this goal, a total of six bridge decks were chosen for study. The decks have ages that vary from 4 to 30 years old, are all in good condition, though some presented a variety of longitudinal, transverse and diagonal cracking. In each deck, test segments were laid out along one lane in four of the six bridges. Drill powder samples were extracted in each segment in order to determine the in-situ, near-surface chloride ion content of the deck. Laboratory analyses of the samples showed that the chloride ion content varied between 3.2 lb/cy for the younger decks (3 years old) and 20.8 lb/cy for the older decks (28 years old). Based on the recommendations of a previous laboratory investigation, a pool of the best performing deck and crack sealants were selected to be applied in the decks. In two bridges, deck segments were sealed with four deck sealants while one segment was left unsealed to be used as a control segment. Additionally, the cracks in each of these segments were sealed with five crack sealants. While two other decks were also scheduled for sealing as part of this phase of the project, they were not done because the required curing time for some of the products was longer than deemed acceptable by DOT crews for these high traffic bridges. It is recommended, however, that every effort be made to have these decks be sealed in the near future. The remaining two bridges had been sealed at the time of construction. While no specific information could be secured about the product used in these decks, the low chloride ion content in these decks suggested that the applied product has helped reduce the ingress of chloride ions. Therefore, it is recommended that these decks continue to be monitored over time. Based on the inspections and the data collected in the field, a protocol and schedule for the continuing monitoring of sealant performance is presented.
Download or read book Protective Coatings for Concrete Bridge Decks written by Richard J. Irwin and published by . This book was released on 1969 with total page 36 pages. Available in PDF, EPUB and Kindle. Book excerpt: Performance of protective coatings for bridge decks is evaluated. Applications to bridges on the New York State highway system from 1961 through 1967 included 1) surface overlays, 2) membranes between the structural slab and bituminous wearing course, and 3) surface sealants. Overlays and membranes consisted of epoxies, polyesters, polyurethanes, latexes, neoprenes, silicone rubbers, and asphalt cutbacks. Surface sealants included silicones, distillate oils, and linseed oil. None of the surface overlays lasted more than 2 to 3 yr. However, a flexible polyester resin with fiber glass has provided satisfactory service for 1-1/2 yr and will remain under observation. Leakage of box-girder bridges with a membrane was primarily due to shear-key construction (since modified), while the same materials applied to composite bridges were associated with leakage that could not be explained. A more comprehensive survey of membranes is planned. Silicone and distillate oil sealants on non-air-entrained concrete did not improve long-term durability. Air-entrained concrete, both with and without linseed oil treatment, showed no evidence of deterioration after 4 yr of exposure.
Download or read book Bridge Safety Maintenance Management Life Cycle Resilience and Sustainability written by Joan Ramon Casas and published by CRC Press. This book was released on 2022-06-26 with total page 5491 pages. Available in PDF, EPUB and Kindle. Book excerpt: Bridge Safety, Maintenance, Management, Life-Cycle, Resilience and Sustainability contains lectures and papers presented at the Eleventh International Conference on Bridge Maintenance, Safety and Management (IABMAS 2022, Barcelona, Spain, 11–15 July, 2022). This e-book contains the full papers of 322 contributions presented at IABMAS 2022, including the T.Y. Lin Lecture, 4 Keynote Lectures, and 317 technical papers from 36 countries all around the world. The contributions deal with the state-of-the-art as well as emerging concepts and innovative applications related to the main aspects of safety, maintenance, management, life-cycle, resilience, sustainability and technological innovations of bridges. Major topics include: advanced bridge design, construction and maintenance approaches, safety, reliability and risk evaluation, life-cycle management, life-cycle, resilience, sustainability, standardization, analytical models, bridge management systems, service life prediction, structural health monitoring, non-destructive testing and field testing, robustness and redundancy, durability enhancement, repair and rehabilitation, fatigue and corrosion, extreme loads, needs of bridge owners, whole life costing and investment for the future, financial planning and application of information and computer technology, big data analysis and artificial intelligence for bridges, among others. This volume provides both an up-to-date overview of the field of bridge engineering and significant contributions to the process of making more rational decisions on bridge safety, maintenance, management, life-cycle, resilience and sustainability of bridges for the purpose of enhancing the welfare of society. The volume serves as a valuable reference to all concerned with and/or involved in bridge structure and infrastructure systems, including students, researchers and practitioners from all areas of bridge engineering.
Download or read book Waterproofing Membranes for Concrete Bridge Decks written by David G. Manning and published by Transportation Research Board. This book was released on 1995 with total page 80 pages. Available in PDF, EPUB and Kindle. Book excerpt: This synthesis will be of interest to research, specifications, materials, design, and construction engineers; contract and specification administrators; agency project managers and staff; and concrete bridge deck construction contractors. This synthesis describes the state of the practice with respect to the development and present status of waterproofing membranes for concrete bridge decks. This report of the Transportation Research Board describes the use of waterproofing systems applied to new bridge decks and the rehabilitation of deteriorated concrete bridge decks. In addition, this synthesis describes current practice with regard to methods for assessing the effectiveness of membranes, criteria for use, installation practices, and factors that affect the performance of waterproofing systems in new construction and rehabilitation. Suggestions for future research are also included.
Download or read book Crack and Concrete Deck Sealant Performance written by Karl Andrew Johnson and published by . This book was released on 2013 with total page 184 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Developing Material Specification and Application Criteria for Sealing Concrete Bridge Decks written by Danny Wells and published by . This book was released on 2019 with total page 14 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Evaluation of Penetrating Surface Treatments of Bridge Deck Concretes written by T. S. Rutkowski and published by . This book was released on 1988 with total page 0 pages. Available in PDF, EPUB and Kindle. Book excerpt: The purpose of this study was to develop a laboratory procedure that would determine the degree to which a surface treatment (sealer) will protect the substrate of a concrete bridge deck from penetration of moisture in general and chloride ions in particular. The study included absorption tests, resistance to chloride ion penetration tests, vapor permeability tests, a rapid electrical cell test procedure, and an impressed voltage test procedure. The individual test procedures, with the exception of the rapid electrical cell tests, effectively differentiated between the proprietary sealers. However, it was not possible to extrapolate the laboratory test results to years of sealer field performance. None of the applied sealers appeared to be able to completely stop the penetration of moisture or chloride ions into the concrete substrate.
Download or read book Performance Evaluation of Various Corrosion Protection Systems of Bridges in Colorado written by Yunping Xi and published by . This book was released on 2004 with total page 166 pages. Available in PDF, EPUB and Kindle. Book excerpt: Corrosion of reinforced concrete structures has been a significant problem for many state and transportation agencies since the application of deicing salts was introduced. Much research has been conducted to develop corrosion protection systems that can prolong the life span of reinforced concrete structures. The Colorado Department of Transportation (CDOT) has several routine and experimental measures to prevent corrosion of the rebar including epoxy-coated rebar, calcium nitrite admixture, organic corrosion inhibitors, a thick cover of quality concrete, and a waterproofing membrane covered by an asphalt overlay. An extensive literature review was performed to collect information on various corrosion protection systems that have been used in the U.S. and around the world. Current CDOT practices in terms of corrosion protection measures were reviewed. A draft inspection plan for Colorado's bridge structures was proposed.
Download or read book Evaluation of Sealers for Concrete Bridge Decks written by William Curra and published by . This book was released on 1990 with total page 41 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Extended Evaluation of Selected Experimental Bridge Deck Protective Systems written by M. G. Hagen and published by . This book was released on 1988 with total page 34 pages. Available in PDF, EPUB and Kindle. Book excerpt:
