Download or read book Review Criteria for Successful Treatment of Hydrolysate at the Blue Grass Chemical Agent Destruction Pilot Plant written by National Academies of Sciences, Engineering, and Medicine and published by National Academies Press. This book was released on 2015-10-05 with total page 194 pages. Available in PDF, EPUB and Kindle. Book excerpt: In 1993, the United States signed the Chemical Weapons Convention (CWC), an international treaty outlawing the production, stockpiling, and use of chemical weapons. The chemical weapons stockpiles at five of the U.S. chemical weapons storage sites have now been destroyed. At those sites, the munitions were robotically opened and the chemical agent was removed, collected, and incinerated. One of the remaining sites with chemical weapons stockpiles is the Blue Grass Army Depot near Richmond, Kentucky. In this case, caustic hydrolysis will be used to destroy the agents and energetics, resulting in a secondary waste stream known as hydrolysate. Review Criteria for Successful Treatment of Hydrolysate at the Blue Grass Chemical Agent Destruction Pilot Plant develops criteria for successfully treating the hydrolysate, identifies systemization data that should factor into the criteria/decision process, suggests potential modifications to suggested treatment that would allow continued onsite processing, and assesses waste disposal procedures. This study further examines the possibility of delay or failure of the existing technology and examines possible alternatives to onsite treatment.
Download or read book Review Criteria for Successful Treatment of Hydrolysate at the Pueblo Chemical Agent Destruction Pilot Plant written by National Research Council and published by National Academies Press. This book was released on 2015-03-26 with total page 150 pages. Available in PDF, EPUB and Kindle. Book excerpt: One of the last two sites with chemical munitions and chemical materiel is the Pueblo Chemical Depot in Pueblo, Colorado. The stockpile at this location consists of about 800,000 projectiles and mortars, all of which are filled with the chemical agent mustard. Under the direction of the Assembled Chemical Weapons Alternative Program (ACWA), the Army has constructed the Pueblo Chemical Agent Destruction Pilot Plant (PCAPP) to destroy these munitions. The primary technology to be used to destroy the mustard agent at PCAPP is hydrolysis, resulting in a secondary waste stream referred to as hydrolysate. PCAPP features a process that will be used to treat the hydrolysate and the thiodiglycol - a breakdown product of mustard - contained within. The process is a biotreatment technology that uses what are known as immobilized cell bioreactors. After biodegradation, the effluent flows to a brine reduction system, producing a solidified filter cake that is intended to be sent offsite to a permitted hazardous waste disposal facility. Water recovered from the brine reduction system is intended to be recycled back through the plant, thereby reducing the amount of water that is withdrawn from groundwater. Although biotreatment of toxic chemicals, brine reduction, and water recovery are established technologies, never before have these technologies been combined to treat mustard hydrolysate. At the request of the U.S. Army, Review Criteria for Successful Treatment of Hydrolysate at the Pueblo Chemical Agent Destruction Pilot Plant reviews the criteria for successfully treating the hydrolysate. This report provides information on the composition of the hydrolysate and describes the PCAPP processes for treating it; discusses stakeholder concerns; reviews regulatory considerations at the federal, state, and local levels; discusses Department of Transportation regulations and identifies risks associated with the offsite shipment of hydrolysate; establishes criteria for successfully treating the hydrolysate and identifies systemization data that should factor into the criteria and decision process for offsite transport and disposal of the hydrolysate; and discusses failure risks and contingency options as well as the downstream impacts of a decision to ship hydrolysate offsite.
Download or read book Review Criteria for Successful Treatment of Hydrolysate at the Pueblo Chemical Agent Destruction Pilot Plant written by National Research Council (U.S.). Committee On Review Criteria for Successful Treatment of Hydrolysate at the Pueblo and Blue Grass Chemical Agent Destruction Pilot Plant and published by . This book was released on 2015 with total page 85 pages. Available in PDF, EPUB and Kindle. Book excerpt: "One of the last two sites with chemical munitions and chemical materiel is the Pueblo Chemical Depot in Pueblo, Colorado. The stockpile at this location consists of about 800,000 projectiles and mortars, all of which are filled with the chemical agent mustard. Under the direction of the Assembled Chemical Weapons Alternative Program (ACWA), the Army has constructed the Pueblo Chemical Agent Destruction Pilot Plant (PCAPP) to destroy these munitions. The primary technology to be used to destroy the mustard agent at PCAPP is hydrolysis, resulting in a secondary waste stream referred to as hydrolysate. PCAPP features a process that will be used to treat the hydrolysate and the thiodiglycol - a breakdown product of mustard - contained within. The process is a biotreatment technology that uses what are known as immobilized cell bioreactors. After biodegradation, the effluent flows to a brine reduction system, producing a solidified filter cake that is intended to be sent offsite to a permitted hazardous waste disposal facility. Water recovered from the brine reduction system is intended to be recycled back through the plant, thereby reducing the amount of water that is withdrawn from groundwater. Although biotreatment of toxic chemicals, brine reduction, and water recovery are established technologies, never before have these technologies been combined to treat mustard hydrolysate. At the request of the U.S. Army, Review Criteria for Successful Treatment of Hydrolysate at the Pueblo Chemical Agent Destruction Pilot Plant reviews the criteria for successfully treating the hydrolysate. This report provides information on the composition of the hydrolysate and describes the PCAPP processes for treating it; discusses stakeholder concerns; reviews regulatory considerations at the federal, state, and local levels; discusses Department of Transportation regulations and identifies risks associated with the offsite shipment of hydrolysate; establishes criteria for successfully treating the hydrolysate and identifies systemization data that should factor into the criteria and decision process for offsite transport and disposal of the hydrolysate; and discusses failure risks and contingency options as well as the downstream impacts of a decision to ship hydrolysate offsite."--Publisher's description.
Download or read book Assessment of Supercritical Water Oxidation System Testing for the Blue Grass Chemical Agent Destruction Pilot Plant written by National Research Council and published by National Academies Press. This book was released on 2013-10-10 with total page 119 pages. Available in PDF, EPUB and Kindle. Book excerpt: Assessment of Supercritical Water Oxidation System Testing for the Blue Grass Chemical Agent Destruction Pilot Plant reviews and evaluates the results of the tests conducted on one of the SCWO units to be provided to Blue Grass Chemical Agent Destruction Pilot Plant. The Army Element, Assembled Chemical Weapons Alternatives (ACWA) is responsible for managing the conduct of destruction operations for the remaining 10 percent of the nation's chemical agent stockpile, stored at the Blue Grass Army Depot (Kentucky) and the Pueblo Chemical Depot (Colorado). Facilities to destroy the agents and their associated munitions are currently being constructed at these sites. The Blue Grass Chemical Agent Destruction Pilot Plant (BGCAPP) will destroy chemical agent and some associated energetic materials by a process of chemical neutralization known as hydrolysis. The resulting chemical waste stream is known as hydrolysate. Among the first-of-a-kind equipment to be installed at BGCAPP are three supercritical water oxidation (SCWO) reactor systems. These particular hydrolysate feeds present unique non-agent-related challenges to subsequent processing via SCWO due to their caustic nature and issues of salt management.This report provides recommendations on SCWO systemization testing inclusive of durability testing and discusses systemization testing objectives and concepts.
Download or read book Alternatives for the Demilitarization of Conventional Munitions written by National Academies of Sciences, Engineering, and Medicine and published by National Academies Press. This book was released on 2019-01-11 with total page 133 pages. Available in PDF, EPUB and Kindle. Book excerpt: The U.S. military has a stockpile of approximately 400,000 tons of excess, obsolete, or unserviceable munitions. About 60,000 tons are added to the stockpile each year. Munitions include projectiles, bombs, rockets, landmines, and missiles. Open burning/open detonation (OB/OD) of these munitions has been a common disposal practice for decades, although it has decreased significantly since 2011. OB/OD is relatively quick, procedurally straightforward, and inexpensive. However, the downside of OB and OD is that they release contaminants from the operation directly into the environment. Over time, a number of technology alternatives to OB/OD have become available and more are in research and development. Alternative technologies generally involve some type of contained destruction of the energetic materials, including contained burning or contained detonation as well as contained methods that forego combustion or detonation. Alternatives for the Demilitarization of Conventional Munitions reviews the current conventional munitions demilitarization stockpile and analyzes existing and emerging disposal, treatment, and reuse technologies. This report identifies and evaluates any barriers to full-scale deployment of alternatives to OB/OD or non-closed loop incineration/combustion, and provides recommendations to overcome such barriers.
Download or read book Risk Conundrums written by Roger E Kasperson and published by Taylor & Francis. This book was released on 2017-07-14 with total page 299 pages. Available in PDF, EPUB and Kindle. Book excerpt: A risk conundrum can be viewed as a risk that poses major issues in assessment, and whose management is not easily engaged. Such perplexing problems can either paralyze or badly delay risk analysis and directions for progression. Rather than simply focusing on the progress in risk analysis that has already been made, it is crucial to consider what has been learnt about these seemingly unmanageable problems and how best to move forward. Risk Conundrums seeks to answer this question by bringing together a range of key thinkers in the field to explore key issues such as risk communication, uncertainty, social trust, indicators and metrics, and risk management, drawing upon case study examples including natural disasters, terrorism, and energy transitions. The initial chapters address risk conundrums, their properties, and the challenges they pose. The book then turns to a greater emphasis on systemic and regional risk conundrums. Finally, it considers how risk management can be changed to address these unsolvable conundrums. Alternative pathways are defined and scrutinized and predictions for future developments set out. This book will be of great interest to students and scholars of risk governance, environmental policy, and sustainable development.
Download or read book Review of Biotreatment Water Recovery and Brine Reduction Systems for the Pueblo Chemical Agent Destruction Pilot Plant written by National Research Council and published by National Academies Press. This book was released on 2013-06-17 with total page 61 pages. Available in PDF, EPUB and Kindle. Book excerpt: The Pueblo Chemical Depot (PCD) in Colorado is one of two sites that features U.S. stockpile of chemical weapons that need to be destroyed. The PCD features about 2,600 tons of mustard-including agent. The PCD also features a pilot plant, the Pueblo Chemical Agent Destruction Pilot Plant (PCAPP), which has been set up to destroy the agent and munition bodies using novel processes. The chemical neutralization or hydrolysis of the mustard agent produces a Schedule 2 compound called thiodiglycol (TDG) that must be destroyed. The PCAPP uses a combined water recovery system (WRS) and brine reduction system (BRS) to destroy TDG and make the water used in the chemical neutralization well water again. Since the PCAPP is using a novel process, the program executive officer for the Assembled Chemical Weapons Alternatives (ACWA) program asked the National Research Council (NRC) to initiate a study to review the PCAPP WRS-BRS that was already installed at PCAPP. 5 months into the study in October, 2012, the NRC was asked to also review the Biotreatment area (BTA). The Committee on Review of Biotreatment, Water Recovery, and Brine Reduction Systems for the Pueblo Chemical Agent Destruction Pilot Plant was thus tasked with evaluating the operability, life-expectancy, working quality, results of Biotreatment studies carried out prior to 1999 and 1999-2004, and the current design, systemization approached, and planned operation conditions for the Biotreatment process. Review of Biotreatment, Water Recovery, and Brine Reduction Systems for the Pueblo Chemical Agent Destruction Pilot Plant is the result of the committee's investigation. The report includes diagrams of the Biotreatment area, the BRS, and WRS; a table of materials of construction, the various recommendations made by the committee; and more.
Download or read book Review of Secondary Waste Disposal Planning for the Blue Grass and Pueblo Chemical Agent Destruction Pilot Plants written by National Research Council and published by National Academies Press. This book was released on 2008-12-14 with total page 84 pages. Available in PDF, EPUB and Kindle. Book excerpt: The U.S. Army Program Manager for Assembled Chemical Weapons Alternatives (PMACWA) is charged with disposing of chemical weapons as stored at two sites: Pueblo, Colorado, and Blue Grass, Kentucky. In accordance with congressional mandates, technologies other than incineration are to be used if they are as safe and as cost effective. The weapons are to be disposed of in compliance with the Chemical Weapons Convention. Although an element of the U.S. Army, the PMACWA is responsible to the Assistant Secretary of Defense for Acquisitions, Technology, and Logistics for completing this mission. This book deals with the expected significant quantities of secondary wastes that will be generated during operations of the facilities and their closure. While there are only estimates for the waste quantities that will be generated, they provide a good basis for planning and developing alternatives for waste disposal while the plants are still in the design phase. Establishing efficient disposal options for the secondary wastes can enable more timely and cost-effective operation and closure of the facilities.
Download or read book Review of the Water Recovery System for the Blue Grass Chemical Agent Destruction Pilot Plant written by and published by . This book was released on 2012 with total page 52 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Metrics for Successful Supercritical Water Oxidation System Operation at the Blue Grass Chemical Agent Destruction Pilot Plant written by Engineering National Academies of Sciences (and Medicine) and published by . This book was released on 2019 with total page 30 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Letter Report on the Blue Grass Chemical Agent Destruction Pilot Plant s Water Recovery System written by National Research Council (U.S.). Committee to Review the Water Recovery System for the Blue Grass Chemical Agent Destruction Pilot Plant and published by . This book was released on 2012 with total page 52 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Letter Report on the Blue Grass Chemical Agent Destruction Pilot Plant s Water Recovery System written by and published by . This book was released on 2012 with total page 52 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Disposal Options for the Rocket Motors From Nerve Agent Rockets Stored at Blue Grass Army Depot written by Committee on Disposal Options for the Rocket Motors of Nerve Agent Rockets at Blue Grass Army Depot and published by National Academies Press. This book was released on 2012-11-01 with total page 97 pages. Available in PDF, EPUB and Kindle. Book excerpt: The Blue Grass Chemical Agent-Destruction Pilot Plant (BGCAPP) is under construction near Richmond, Kentucky, two dispose of one of the two remaining stockpiles of chemical munitions in the United States. The stockpile that BGCAPP will dispose of is stored at the Blue Grass Army Depot (BGAD). BGCAPP is a tenant activity on BGAD. The stockpile stored at BGAD consists of mustard agent loaded in projectiles, and the nerve agents GB and VX loaded into projectiles and M55 rockets. BGCAPP will process the rockets by cutting them, still in their shipping and firing tube (SFT), between the warhead and motor sections of the rocket. The warhead will be processed through BGCAPP. The separated rocket motors that have been monitored for chemical agent and cleared for transportation outside of BGCAPP, the subject of this report, will be disposed of outside of BGCAPP. Any motors found to be contaminated with chemical agent will be processed through BGCAPP and are not addressed in this report. Disposal Options for the Rocket Motors From Nerve Agent Rockets Stored at Blue Grass Army Depot addresses safety in handling the separated rocket motors with special attention to the electrical ignition system, the need for adequate storage space for the motors in order to maintain the planned disposal rate at BGCAPP, thermal and chemical disposal technologies, and on-site and off-site disposal options. On-site is defined as disposal on BGAD, and off-site is defined as disposal by a commercial or government facility outside of BGAD.
Download or read book Counter Unmanned Aircraft System CUAS Capability for Battalion and Below Operations written by National Academies of Sciences, Engineering, and Medicine and published by National Academies Press. This book was released on 2018-03-29 with total page 49 pages. Available in PDF, EPUB and Kindle. Book excerpt: The development of inexpensive small unmanned aircraft system (sUAS) technologies and the growing desire of hobbyists to have more and more capability have created a sustained sUAS industry, however these capabilities are directly enabling the ability of adversaries to threaten U.S. interests. In response to these threats, the U.S. Army and other Department of Defense (DoD) organizations have invested significantly in counter-sUAS technologies, often focusing on detecting radio frequency transmissions by sUASs and/or their operators, and jamming the radio frequency command and control links and Global Positioning System signals of individual sUASs. However, today's consumer and customized sUASs can increasingly operate without radio frequency command and control links by using automated target recognition and tracking, obstacle avoidance, and other software-enabled capabilities. The U.S. Army tasked the National Academies of Sciences, Engineering, and Medicine to conduct a study to address the above concerns. In particular, the committee was asked to assess the sUAS threat, particularly when massed and collaborating; assess current capabilities of battalion-and- below infantry units to counter sUASs; identify counter-sUAS technologies appropriate for near- term, mid-term, and far-term science and technology investment; consider human factors and logistics; and determine if the Department of Homeland Security could benefit from DoD efforts. This abbreviated report provides background information on the full report and the committee that prepared it.
Download or read book Making the Soldier Decisive on Future Battlefields written by National Research Council and published by National Academies Press. This book was released on 2013-06-10 with total page 256 pages. Available in PDF, EPUB and Kindle. Book excerpt: The U.S. military does not believe its soldiers, sailors, airmen, and marines should be engaged in combat with adversaries on a "level playing field." Our combat individuals enter engagements to win. To that end, the United States has used its technical prowess and industrial capability to develop decisive weapons that overmatch those of potential enemies. In its current engagement-what has been identified as an "era of persistent conflict"- the nation's most important weapon is the dismounted soldier operating in small units. Today's soldier must be prepared to contend with both regular and irregular adversaries. Results in Iraq and Afghanistan show that, while the U.S. soldier is a formidable fighter, the contemporary suite of equipment and support does not afford the same high degree of overmatch capability exhibited by large weapons platforms-yet it is the soldier who ultimately will play the decisive role in restoring stability. Making the Soldier Decisive on Future Battlefields establishes the technical requirements for overmatch capability for dismounted soldiers operating individually or in small units. It prescribes technological and organizational capabilities needed to make the dismounted soldier a decisive weapon in a changing, uncertain, and complex future environment and provides the Army with 15 recommendations on how to focus its efforts to enable the soldier and tactical small unit (TSU) to achieve overmatch.
Download or read book Guidelines for Process Safety Metrics written by CCPS (Center for Chemical Process Safety) and published by John Wiley & Sons. This book was released on 2009-12-17 with total page 200 pages. Available in PDF, EPUB and Kindle. Book excerpt: Process safety metrics is a topic of frequent conversation within chemical industry associations. Guidelines for Process Safety Metrics provides basic information on process safety performance indicators, including a comprehensive list of metrics for measuring performance and examples as to how they can be successfully applied over both the short and long term. For engineers, insurers, corporate traininers, military personnel, government officials, students, and managers involved in production, product and process development, Guidelines for Process Safety Metrics can help determine appropriate metrics useful in monitoring performance and improving process safety programs. Note: CD-ROM/DVD and other supplementary materials are not included as part of eBook file.
Download or read book Network Science written by National Research Council and published by National Academies Press. This book was released on 2006-01-15 with total page 125 pages. Available in PDF, EPUB and Kindle. Book excerpt: The military is currently attempting to develop itself into a force capable of networkcentric operations. While this effort has highlighted the military's dependence on interacting networks, it has also shown that there is a huge gap between what we need to know about networks and our fundamental knowledge about network behavior. This gap makes the military vision of NCO problematic. To help address this problem, the Army asked the NRC to find out whether identifying and funding a new field of "network science" could help close this gap. This report presents an examination of networks andthe military, an analysis of the promise, content, and challenges of network science, and an assessment of approaches to creating value from network science.
