Download or read book Anaerobic digestion in the kraft pulp and paper industry written by Eva-Maria Ekstrand and published by Linköping University Electronic Press. This book was released on 2019-05-07 with total page 50 pages. Available in PDF, EPUB and Kindle. Book excerpt: The pulp and paper industry is a large producer of wastewater and sludge, putting high pressure on waste treatment. In addition, more rigorous environmental legislation for pollution control and demands to increase the use of renewable energy have put further pressure on the pulp and paper industry’s waste treatment, where anaerobic digestion (AD) and the production of methane could pose a solution. Kraft pulping makes up 80% of the world production of virgin wood pulp, thus, the wastewaters from this sector represent a large unused potential for methane production. There are three main types of substrates available for AD at pulp and paper mills, the wastewaters, the primary sludge/fibre sludge, and the waste activated sludge. AD treatment of these streams has been associated with several challenges, such as the presence of inhibiting compounds or low degradability during AD. The aim of this thesis was to experimentally address these challenges and potentials, focusing on wastes from kraft mills. Methane potential batch tests showed that many wastewater streams still posed challenges to AD, but the alkaline elemental chlorine-free bleaching stream and the condensate effluents had good methane potentials. Further, the methane potential of kraft mill fibre sludge was high, and co-digestion of kraft mill fibre sludge and waste activated sludge was feasible in stirred tank reactors with sludge recirculation. By increasing the organic loading in a pilot-scale activated sludge facility and thereby lowering the sludge age, the degradability of the waste activated sludge was improved. The higher wastewater treatment capacity achieved by this method provides an opportunity for the mills to increase their pulp and paper production. Further, by dewatering the digestate after AD and returning the liquid to the activated sludge treatment, costs for nutrient supplementation can be reduced. In conclusion, the thesis shows that AD of wastes from the kraft pulp and paper industry was feasible and carried many benefits regarding the generation of methane as a renewable energy carrier, improved wastewater treatment and reduced costs. Different strategies on how AD may be implemented in the kraft pulp and paper industry were formulated and discussed. Produktionen av pappers- och massa genererar stora mängder avloppsvatten, vilket ställer höga krav på en effektiv vattenrening. Därtill har skärpta regler för utsläpp till vatten och luft tillsammans med en ökad efterfrågan på användning av förnyelsebar energi ytterligare ökat trycket på vattenreningen inom pappers-och massaindustrin, där anaerob nedbrytning med metanproduktion som följd skulle kunna utgöra en lösning. Produktionen av sulfatmassa (en kemiskt kokad pappersmassa) utgör 80% av den globala nyproduktionen av massa, vilket innebär att avloppsvatten från denna sektor representerar en stor outnyttjad potential för metanproduktion. Det finns huvudsakligen tre typer av substrat tillgängliga för rötning vid pappers- och massabruk, avloppsvatten, primärslam/fiberslam, och aktivt slam/överskottsslam. Flera utmaningar är kopplade till anaerob nedbrytning av dess strömmar, såsom förekomst av inhiberande ämnen eller låg nedbrytbarhet. Målet med avhandlingen var att bemöta dessa utmaningar, med ett särskilt fokus på behandling av avloppsströmmar från sulfatbruk. Metanpotentialtester visade att många av avloppsvattnen fortfarande var svåra att behandla med anaerob nedbrytning, men att alkaliska blekeriströmmar och kondensatströmmar vid sulfatbruk visade lovande metanpotentialer. Massafiber från sulfatoch sulfitbruk uppvisade höga metanpotentialer, och en stabil kontinuerlig samrötning av fiberslam och aktivt slam från sulfatbruk uppnåddes vid hög organisk belastning och låg hydraulisk uppehållstid i omrörda tankreaktorer med slamåterföring. Resultaten visade vidare att den låga nedbrytbarheten hos aktivt slam kunde bemötas genom att sänka slamåldern i den luftade anläggningen, med högre metanpotential i slammet som följd. Via denna metodik erhålles en högre vattenreningskapacitet, vilket innebär att bruken kan öka sin produktion av papper och massa. Dessutom kan rötresten avvattnas och den kvarvarande vätskan återföras till den luftade anläggningen för att minska behovet av näringstillsatser. Sammanfattningsvis visar avhandlingen att anaerob nedbrytning av avloppsströmmar från sulfatbruk var fullt möjlig och innebar många fördelar, i form av metanproduktion, förbättrad kapacitet för vattenrening och reducerade kostnader jämfört med dagens teknik. Olika möjligheter för implementering av anaerob teknik vid sulfatbruk har också formulerats och diskuterats.
Download or read book Anaerobic Technology in Pulp and Paper Industry written by Pratima Bajpai and published by Springer. This book was released on 2017-03-14 with total page 106 pages. Available in PDF, EPUB and Kindle. Book excerpt: This book presents a state-of-the-art report on the treatment of pulp and paper industry effluents using anaerobic technology. It covers a comprehensive range of topics, including the basic reasons for anaerobic treatment, comparison between anaerobic and aerobic treatment, effluent types suitable for anaerobic treatment, design considerations for anaerobic treatment, anaerobic reactor configurations applied for treatment of pulp and paper industry effluents, present status of anaerobic treatment in pulp and paper industry, economic aspects, examples of full scale installations and future trends.
Download or read book Anaerobic Digestion of Kraft Pulp and Paper Mill Sludges written by Donald C. Taylor and published by . This book was released on 1990 with total page 490 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Anaerobic Digestion Model No 1 ADM1 written by IWA Task Group for Mathematical Modelling of Anaerobic Digestion Processes and published by IWA Publishing. This book was released on 2002-02-01 with total page 61 pages. Available in PDF, EPUB and Kindle. Book excerpt: The IWA Task Group for Mathematical Modelling of Anaerobic Digestion Processes was created with the aim to produce a generic model and common platform for dynamic simulations of a variety of anaerobic processes. This book presents the outcome of this undertaking and is the result of four years collaborative work by a number of international experts from various fields of anaerobic process technology. The purpose of this approach is to provide a unified basis for anaerobic digestion modelling. It is hoped this will promote increased application of modelling and simulation as a tool for research, design, operation and optimisation of anaerobic processes worldwide. This model was developed on the basis of the extensive but often disparate work in modelling and simulation of anaerobic digestion systems over the last twenty years. In developing ADM1, the Task Group have tried to establish common nomenclature, units and model structure, consistent with existing anaerobic modelling literature and the popular activated sludge models (See Activated Sludge Models ASM1, ASM2, ASM2d and ASM3, IWA Publishing, 2000, ISBN: 1900222248). As such, it is intended to promote widespread application of simulation from domestic (wastewater and sludge) treatment systems to specialised industrial applications. Outputs from the model include common process variables such gas flow and composition, pH, separate organic acids, and ammonium. The structure has been devised to encourage specific extensions or modifications where required, but still maintain a common platform. During development the model has been successfully tested on a range of systems from full-scale waste sludge digestion to laboratory-scale thermophilic high-rate UASB reactors. The model structure is presented in a readily applicable matrix format for implementation in many available differential equation solvers. It is expected that the model will be available as part of commercial wastewater simulation packages. ADM1 will be a valuable information source for practising engineers working in water treatment (both domestic and industrial) as well as academic researchers and students in Environmental Engineering and Science, Civil and Sanitary Engineering, Biotechnology, and Chemical and Process Engineering departments. Contents Introduction Nomenclature, State Variables and Expressions Biochemical Processes Physicochemical Processes Model Implementation in a Single Stage CSTR Suggested Biochemical Parameter Values, Sensitivity and Estimation Conclusions References Appendix A: Review of Parameters Appendix B: Supplementary Matrix Information Appendix C: Integration with the ASM Appendix D: Estimating Stoichiometric Coefficients for Fermentation Scientific & Technical Report No.13
Download or read book Pulp and Paper Industry written by Pratima Bajpai and published by Elsevier. This book was released on 2017-02-25 with total page 230 pages. Available in PDF, EPUB and Kindle. Book excerpt: Pulp and Paper Industry: Emerging Waste Water Treatment Technologies is the first book which comprehensively reviews this topic. Over the past decade, pulp and paper companies have continued to focus on minimizing fresh water use and effluent discharges as part of their move towards sustainable operating practices. Three stages—basic conservation, water reuse and water recycling—provide a systematic approach to water resource management. Implementing these stages requires increased financial investment and better utilization of water resources. The ultimate goal for pulp and paper companies is to have effluent-free factories with no negative environmental impact. The traditional water treatment technologies that are used in paper mills are not able to remove recalcitrant contaminants. Therefore, advanced water treatment technologies are being included in industrial wastewater treatment chains aiming to either improve water biodegradability or its final quality. This book discusses various measures being adopted by the pulp and paper industry to reduce water consumption and treatment techniques to treat wastewater to recover it for reuse. The book also examines the emerging technologies for treatment of effluents and presents examples of full-scale installations. - Provides thorough and in-depth coverage of advanced treatment technologies which will benefit the industry personnel, pulp manufacturers, researchers and advanced students - Presents new treatment strategies to improve water reuse and fulfill the legislation in force regarding wastewater discharge - Presents viable solutions for pulp and paper manufacturers in terms of wastewater treatment - Presents examples of full-scale installations to help motivate mill personnel to incorporate new technologies
Download or read book The Practical Handbook of Compost Engineering written by RogerTim Haug and published by Routledge. This book was released on 2018-05-04 with total page 745 pages. Available in PDF, EPUB and Kindle. Book excerpt: The Practical Handbook of Compost Engineering presents an in-depth examination of the principles and practice of modern day composting. This comprehensive book covers compost science, engineering design, operation, principles, and practice, stressing a fundamental approach to analysis throughout. Biological, physical, chemical, thermodynamic, and kinetic principles are covered to develop a unified analytical approach to analysis and an understanding of the process. A brief history of the development of composting systems, which leads to descriptions of modern processes, is presented. The Practical Handbook of Compost Engineering also discusses the elements of successful odor management at composting facilities, including state-of-the-art odor treatment and enhanced atmospheric dispersion. The book is excellent for all engineers, practitioners, plant operators, scientists, researchers, and students in the field.
Download or read book Biovalorisation of Wastes to Renewable Chemicals and Biofuels written by R. Navanietha Krishnaraj and published by . This book was released on 2019-10-25 with total page 422 pages. Available in PDF, EPUB and Kindle. Book excerpt: Biovalorisation of Wastes to Renewable Chemicals and Biofuels addresses advanced technologies for converting waste to biofuels and value-added products. Biovalorisation has several advantages over conventional bioremediation processes as it helps reduce the costs of bioprocesses. Examples are provided of several successfully commercialized technologies, giving insight into developing, potential processes for biovalorisation of different wastes. Different bioprocess strategies are discussed for valorising the wastes coming from the leather industry, olive oil industry, pulp and paper, winery, textile, and food industries, as well as aquaculture. A section on biorefinery for hydrocarbons and emerging contaminants is included to cover concepts on biodesulfurization of petroleum wastes, leaching of heavy metals from E - waste, and bioelectrochemical processes for CO2. Chapters on algal biorefinery are also included to focus on the technologies for conversion of CO2 sequestration and wastewater utilization. Biovalorisation of Wastes to Renewable Chemicals and Biofuels can be used as course material for graduate students in chemical engineering, chemistry, and biotechnology, and as a reference for industrial professionals and researchers who want to gain a basic understanding on the subject. Covers a wide range of topics, from the conversion of wastes to organic acids, biofuels, biopolymers and industrially relevant products Bridges the gap between academics and industry Written in a lucid and self-explanatory style Includes activities/quiz/critical questions
Download or read book Selected Water Resources Abstracts written by and published by . This book was released on 1991 with total page 962 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Environmentally Friendly Technologies for the Pulp and Paper Industry written by Raymond A. Young and published by John Wiley & Sons. This book was released on 1997-11-19 with total page 594 pages. Available in PDF, EPUB and Kindle. Book excerpt: Solving the pulp and paper industries' environmental problems is essential to maintaining the forest industry and accommodating the changing economic needs of forest communities. This book explores the construction of new mills--operating on new technology that does not produce pollutants--which are vital to the pulp and paper industry.
Download or read book Green Pulp and Paper Industry written by Amit Kumar and published by Walter de Gruyter GmbH & Co KG. This book was released on 2021-07-19 with total page 316 pages. Available in PDF, EPUB and Kindle. Book excerpt: This book provides recent developments and future perspectives of pulp and paper processing based on biotechnology to replace conventional environmental unfriendly chemical processes. The use of microorganism and microbial enzymes in various processes such as bleaching, deinking, refining, dissolving pulp, debarking & pitch removal, slime control, wastewater treatment and waste material valorisation are discussed.
Download or read book Treatment of Industrial Effluents written by Mihir Kumar Purkait and published by CRC Press. This book was released on 2019-09-06 with total page 600 pages. Available in PDF, EPUB and Kindle. Book excerpt: To address the issue of discharge of untreated industrial effluent in the water body causing pollution, adoption of cleaner production technologies and waste minimization initiatives are being encouraged. The book explains each related technology elaborately and critically analyses the same from practical application point of view. In-depth characterization, environmental and health effects and treatment of various industrial effluents are discussed with case studies. Limitations, challenges and remedial actions to be taken are included at the end of each chapter. Chapters are arranged as per specific type of effluents from various industries like textile, tannery/leather plant, and oil refinery.
Download or read book Third International Symposium on Anaerobic Digestion 14 19 August 1983 Boston Massachusetts USA written by and published by . This book was released on 1983 with total page 570 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Solar Energy Update written by and published by . This book was released on 1984 with total page 884 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Proceedings of the 44th Industrial Waste Conference May 1989 Purdue University written by John W. Bell and published by CRC Press. This book was released on 2018-02-06 with total page 963 pages. Available in PDF, EPUB and Kindle. Book excerpt: New research-case histories and operating data-on every conceivable facet of today's big problem are detailed in the latest Purdue Book-with unparalleled appropriate, usable information and data for your current industrial waste problems from the May 1989 Conference.
Download or read book Selected Water Resources Abstracts written by and published by . This book was released on 1991 with total page 1424 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Advanced Organic Waste Management written by Subrata Hait and published by Elsevier. This book was released on 2022-01-06 with total page 522 pages. Available in PDF, EPUB and Kindle. Book excerpt: Advanced Organic Waste Management: Sustainable Practices and Approaches provides an integrated holistic approach to the challenges associated with organic waste management, particularly related to sustainability, lifecycle assessment, emerging regulations, and novel approaches for resource and energy recovery. In addition to traditional techniques, such as anaerobic digestion, composting, innovative and emerging techniques of waste recycling like hydrothermal carbonization and vermicomposting are included. The book combines the fundamentals and practices of sustainable organic waste management with successful case studies from developed and developing countries, highlighting practical applications and challenges. Sections cover global organic waste generation, encompassing sources and types, composition and characteristics, focus on technical aspects related to various resource recovery techniques like composting and vermicomposting, cover various waste-to-energy technologies, illustrate various environmental management tools for organic waste, present innovative organic waste management practices and strategies complemented by detailed case studies, introduce the circular bioeconomy approach, and more. - Presents the fundamentals and practices of sustainable, organic waste management, with emerging regulations and up-to-date analysis on environmental management tools such as lifecycle assessment in a comprehensive manner - Offers the latest information on novel concepts and strategies for organic waste management, particularly zero waste and the circular bioeconomy - Includes the latest research findings and future perspectives of innovative and emerging techniques of waste recycling, such as hydrothermal carbonization and vermicomposting
Download or read book Advances in Biofuels and Bioenergy written by Madhugiri Nageswara-Rao and published by BoD – Books on Demand. This book was released on 2018-07-04 with total page 294 pages. Available in PDF, EPUB and Kindle. Book excerpt: The worldwide consumption of fossil fuel continues to increase at unsustainable levels, which will lead to progressive scarcity, if immediate and innovative measures are not taken for its sustainable use. This scarcity necessitates the development of renewable and sustainable alternatives for fossil fuels. A possible solution to today's energy challenges can be provided by biofuels. This book intends to provide the reader with a comprehensive overview of the current status and the future implications of biofuels. Diverse and aptly covered comprehensive information in this book will directly enhance both basic and applied research in biofuels and will particularly be useful for students, scientists, breeders, growers, ecologists, industrialists and policy makers. It will be a valuable reference point to improve biofuels in the areas of ecologically and economically sustainable bioenergy research.
