Download or read book Study of Partial Oxidation of Methanol Over Finely Divided Molybdenum Oxide written by Jong Shik Chung and published by . This book was released on 1984 with total page 514 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book The Partial Oxidation of Methanol to Formaldehyde Over Molybdenum containing Catalysts written by Tsong-Jen Yang and published by . This book was released on 1982 with total page 288 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Partial Oxidation of Methanol to Formaldehyde Over Sb Mo Oxide Catalysts written by Rafael Alfredo Díaz Real and published by . This book was released on 1991 with total page 0 pages. Available in PDF, EPUB and Kindle. Book excerpt: The kinetics of the vapor phase air oxidation of methanol to formaldehyde over molybdenum oxide catalysts, antimony oxide catalyst, and their mixtures (both supported and unsupported), at atmospheric pressure and different operating conditions, have been studied in a fixed-bed integral reactor heated by a fluidized sand bath. The effect of various process variables, namely the process temperature (T), the ratio of catalysts to feed flow rate or space time (W/F), and the ratio of methanol fed to air (R), on conversion and yield have been determined. A screening study at varying operating conditions was performed to determine the optimum composition of a Sb$\sb2\rm O\sb4$-MoO$\sb3$ mixture. On the basis of this study a catalyst containing 67% $\rm Sb\sb2O\sb4$-33% MoO$\sb3$ was selected for the detailed kinetic study of oxidation of methanol to formaldehyde. The operating conditions studied were as follows: temperature in the range 623 to 698 K, space times from 5 to 50 $\rm g\sb{cat}/mol\sb{CH\sb3OH}h\sp{-1},$ and methanol to air ratios in the range 0.04 to 0.10 mol$\rm\sb{CH\sb3OH}h\sp{-1}/mol\sb{air}h\sp{-1}.$ This catalyst proved to be highly active and selective to formaldehyde formation. Yields up to $\sim$100% were obtained. Best operating conditions found were obtained at a space time of 27.5 for a methanol/air ratio of 0.06 and a temperature of 698 K. The rate equation for the oxidation of methanol to formaldehyde was derived on the basis of a two-stage redox mechanism$$\eqalign{\rm CH\sb3OH\sb{(g)} + S\sb{ox}\ {\buildrel{k\sb1}\over{\to}}\ &\rm HCHO\sb{(g)} + H\sb2O\sb{(g)} + S\sb{red}\cr\rm O\sb{2\sb{(g)}} + &\rm S\sb{red}\ {\buildrel{k\sb2}\over{\to}}\ S\sb{ox}\cr}$$where S$\rm\sb{ox}$ represents an active site of lattice oxygen and S$\rm\sb{red}$ represents a reduced site of lattice oxygen. The rate equation for the temperature of 648 to 698 K which correlated the data was$$\rm r = {k\sb1P\sb{M}\over 1+{k\sb1P\sb{M}\over 2k\sb2P\sb{O\sb2}}}$$where k$\sb1$ and k$\sb2$ are the temperature dependent rate constants of steps one and two. The equations relating k$\sb1$ and k$\sb2$ with temperature were$$\eqalign{&\rm ln\ k\sb1 = -6.4039-{6.9153\times10\sp3\over T}\cr&\rm ln\ k\sb2 = -3.0154 + {1.8809\times10\sp3\over T}\cr}$$ Several spectroscopic and analytical techniques, viz, electron spin resonance (ESR), x-ray diffraction spectroscopy (XRD), scanning electron microscopy (SEM), and adsorption studies were used to characterize the catalysts. The surface are of the catalyst used in the kinetic study was 6.1 m$\sp2$/g as determined by the BET method. A preliminary study of the Sb-Mo oxide mixture (load of $\sim$5 wt%) supported on Y zeolite was also carried out. Maximum yield obtained was comparable to that obtained with pure MoO$\sb3.$ A new catalyst has been developed that gave nearly 100% conversion and 100% yield. The industrial potential of this catalyst is very promising.

Download or read book Partial Oxidation of Methanol to Formaldehyde Over Molybdenum tin Oxide Catalysts written by Rowaida George Zoumot and published by . This book was released on 1992 with total page 0 pages. Available in PDF, EPUB and Kindle. Book excerpt: The vapor phase air oxidation of methanol to formaldehyde was investigated over molybdenum oxide, tin oxide and their mixtures in an integral flow reactor at atmospheric pressure between temperature of 513 and 573 K, a space time of 10-40 hr g-cat/g-mol methanol and a molar ratio of 0.04-0.1 mol CH3OH/mol air. Experiments were done under such conditions that the effects of internal and external heat and mass transfer effects were negligible. The effects of several process variables, temperature, space time and methanol/air ratio on the conversion of methanol and the selectivity of the catalyst for formaldehyde production were determined. The results indicated that the impact of the process variables on the conversion, selectivity and yield of formaldehyde were in the following decreasing order T > W/F > R. A screening study indicated the optimum catalyst composition to be 50% SnO2 and 50% MoO3, while conversion increased with temperature and W/F selectivity decreased. This catalyst proved to be highly active and selective to formaldehyde production. Selectivity and yield of up to about 100% were obtained at 100% conversion at a temperature of 553 K, a space time (W/F) of 40 g-cat/g-mol methanol per hour and a molar ratio (R) of 0.04 mol CH3 OH/mol air. The rate expression r=k1P2M 1+k1P2M2k 2PO2 was deduced assuming a steady-state involving two-stage irreversible oxidation-reduction process. It represented the experimental data satisfactorily. Arrhenius plots of the two rate constants gave activation energies of 31.7 and 18.1 kcal/g-mol.

Download or read book Partial Oxidation of Methanol on Molybdenum and Vanadium Oxide Catalysts written by Raúl Miranda and published by . This book was released on 1983 with total page 648 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Partial Oxidation of Methanol to Formaldehyde Over Mo Sn Oxide Catalysts written by Rowaida George Zoumot and published by . This book was released on 1992 with total page 304 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Oxidation of Methanol Over Molybdenum Oxide tungsten Oxide Catalyst written by Satyendra Kumar Jain and published by . This book was released on 1976 with total page 0 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Oxidation of Methanol Over Molybdenum Oxide tungsten Oxide Catalyst written by Jain, Satyendra Kumar and published by 1976.. This book was released on 1976 with total page 214 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Methane Conversion by Oxidative Processes written by Wolf and published by Springer Science & Business Media. This book was released on 2013-11-11 with total page 556 pages. Available in PDF, EPUB and Kindle. Book excerpt: A reasonable case could be made that the scientific interest in catalytic oxidation was the basis for the recognition of the phenomenon of catalysis. Davy, in his attempt in 1817 to understand the science associated with the safety lamp he had invented a few years earlier, undertook a series of studies that led him to make the observation that a jet of gas, primarily methane, would cause a platinum wire to continue to glow even though the flame was extinguished and there was no visible flame. Dobereiner reported in 1823 the results of a similar investigation and observed that spongy platina would cause the ignition of a stream of hydrogen in air. Based on this observation Dobereiner invented the first lighter. His lighter employed hydrogen (generated from zinc and sulfuric acid) which passed over finely divided platinum and which ignited the gas. Thousands of these lighters were used over a number of years. Dobereiner refused to file a patent for his lighter, commenting that "I love science more than money." Davy thought the action of platinum was the result of heat while Dobereiner believed the ~ffect ~as a manifestation of electricity. Faraday became interested in the subject and published a paper on it in 1834; he concluded that the cause for this reaction was similar to other reactions.

Download or read book The Partial Oxidation of Methane to Formaldehyde Over Molybdenum Oxide based Catalysts written by Marianne Rose Smith and published by . This book was released on 1992 with total page 462 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Methane Conversion by Oxidative Processes written by Eduardo E. Wolf and published by Springer. This book was released on 1992 with total page 566 pages. Available in PDF, EPUB and Kindle. Book excerpt: A reasonable case could be made that the scientific interest in catalytic oxidation was the basis for the recognition of the phenomenon of catalysis. Davy, in his attempt in 1817 to understand the science associated with the safety lamp he had invented a few years earlier, undertook a series of studies that led him to make the observation that a jet of gas, primarily methane, would cause a platinum wire to continue to glow even though the flame was extinguished and there was no visible flame. Dobereiner reported in 1823 the results of a similar investigation and observed that spongy platina would cause the ignition of a stream of hydrogen in air. Based on this observation Dobereiner invented the first lighter. His lighter employed hydrogen (generated from zinc and sulfuric acid) which passed over finely divided platinum and which ignited the gas. Thousands of these lighters were used over a number of years. Dobereiner refused to file a patent for his lighter, commenting that "I love science more than money." Davy thought the action of platinum was the result of heat while Dobereiner believed the ~ffect ~as a manifestation of electricity. Faraday became interested in the subject and published a paper on it in 1834; he concluded that the cause for this reaction was similar to other reactions.

Download or read book The Oxidation of Methanol with Air Over Oxide Catalysts written by Wesley Rasmus Peterson and published by . This book was released on 1929 with total page 116 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Fossil Energy Update written by and published by . This book was released on 1985 with total page 842 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Methanol Oxidation on Molybdenum Oxide Catalysts written by Ibrahim Wawata and published by . This book was released on 2015 with total page pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Methanol Oxidation on Transition Elements Oxides written by Abdulmohsen Alshehri and published by . This book was released on 2013 with total page pages. Available in PDF, EPUB and Kindle. Book excerpt: Methanol oxidation to formaldehyde is one of the most important industries in our lives; the reaction occurs on catalyst surface in heterogeneous catalysis. Iron molybdate is the current selective catalyst. However, molybdenum volatilises during methanol oxidation and leaving the catalyst with a low molybdenum ratio, which deactivates the catalyst, a 2.2 Mo: 1Fe iron molybdate catalyst was used instead the stoichiometric catalyst, while yield of formaldehyde cannot be 100%. The goal of this study is to find more selective and more productive catalyst than iron molybdate catalyst, the first step is to find another transition element as selective as molybdenum, because molybdenum is the selective part, and iron is the active part, the resulting iron molybdate catalyst is a selective catalyst to formaldehyde near molybdenum and active near iron. Experimentally, catalysts were prepared using co-precipitation method, however, some doped catalysts were papered by incipient wetness impregnation, also sol-immobilization was used to prepare nano-gold particles on the surfaces of few supports. Catalysts characterizations were carried out within several techniques for the surface analysis (XPS) and bulk analysis (XRD), also the surface area was measured by BET equipment. Raman too was used in this study, while micro-reactor was the reactor to determine selectivity and activity of each catalyst. When molybdenum replaced by vanadium, the catalyst yielded 100% formaldehyde at 200 oC; moreover, tungsten was selective. Likewise, iron was replaced by other active metals such as manganese, copper and bismuth, which are active. Nano-gold improved activity when doped on molybdenum oxide and iron molybdate supports.

Download or read book Dissertation Abstracts International written by and published by . This book was released on 1984 with total page 486 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Oxidation of Methanol Over Molybdenum vanadium Oxide Catalysts written by Mahendra Kumar Dosi and published by . This book was released on 1971 with total page 338 pages. Available in PDF, EPUB and Kindle. Book excerpt: