Download or read book Membrane Fouling in Cold Microfiltration of Skim Milk written by Teng Ju Tan and published by . This book was released on 2014 with total page 118 pages. Available in PDF, EPUB and Kindle. Book excerpt: Microfiltration (MF) can effectively remove microorganisms and somatic cells from milk, increasing the safety and shelf life of milk and dairy products. The main challenge in MF is membrane fouling, which leads to a significant decline in permeate flux over time. This work aimed to elucidate the mechanisms of membrane fouling in cold (6°C) MF of skim milk and optimize a CO2 backpulsing technique that can diminish membrane fouling by physically removing the foulant from the membrane surface. Using 3 injection ports, a CO2 injection frequency of 120 s and an injection duration of 1 s, a permeate flux of 30.02 ± 0.48 L/m2h was obtained after 3 h of MF at a cross-flow velocity of 3.8 m/s, as compared to 25.85 ± 0.99 L/m2h for the control. Additionally, a smaller drop in flux was observed for the optimized CO2 backpulsing process (15.57% after 3 h) as compared to the control (29.83% after 3 h). When MF was conducted at 6 m/s, the permeate flux after 3 h was 82.32 ± 4.42 L/m2h for MF with CO2 backpulsing, as compared to 71.39 ± 4.21 L/m2h for the control. MF with CO2 backpulsing also resulted in a higher transmission of total solids and protein than the control MF. A systematic investigation of the mechanisms of membrane fouling was conducted by identifying the proteins and minerals in four foulant streams: weakly attached external foulants (We), weakly attached internal foulants (Wi), strongly attached external foulants (Se), and strongly attached internal foulants (Si). The foulants were evaluated both after MF (without and with CO2 backpulsing) and after a brief contact between the membrane and milk (adsorption study). The concentration of minerals was very small in all foulant streams, below 2.5 ppm, and likely they do not contribute significantly to membrane fouling in cold MF. Proteomics analysis showed that all major milk proteins were present in all foulant streams. In adsorption trial, [alpha]lactalbumin level in We was higher than in milk, which indicates an affinity of this protein for the membrane material. The serum proteins [alpha]-lactalbumin and bovine serum albumin (BSA) were found in a higher proportion in the "weakly attached" fractions (We and Wi) from the instantaneous adsorption study as compared to the control MF (without CO2 backpulsing), which suggests that caseins were mainly introduced into the fouling layer when transmembrane pressure was applied. Casein concentration did not increase in the foulants from CO2 backpulsing MF, despite the localized decrease in pH caused by the contact with CO 2. More significantly, CO2 backpulsing reduced the total protein concentration in We, with 52.98 ± 4.87 [mu]g/mL for CO2 backpulsing MF as compared to 62.20 ± 10.13 [mu]g/mL for control MF. Overall, the data indicates that CO2 backpulsing resulted in less weakly attached external foulants and possibly less loosely deposited materials on the membrane surface as compared to control MF, which improved permeation through the membrane. The knowledge generated in this study could be used to identify solutions to further minimize membrane fouling and increase the efficiency of milk MF. The CO2 backpulsing technique could be an efficient and affordable solution to mitigate fouling, and is also applicable to other cold membrane filtration processes, such as the MF of juice or beer.

Download or read book Handbook of Membrane Separations written by Anil Kumar Pabby and published by CRC Press. This book was released on 2015-04-09 with total page 868 pages. Available in PDF, EPUB and Kindle. Book excerpt: The Handbook of Membrane Separations: Chemical, Pharmaceutical, Food, and Biotechnological Applications, Second Edition provides detailed information on membrane separation technologies from an international team of experts. The handbook fills an important gap in the current literature by providing a comprehensive discussion of membrane application

Download or read book Dairy Chemistry and Biochemistry written by P. F. Fox and published by Springer. This book was released on 2015-06-19 with total page 598 pages. Available in PDF, EPUB and Kindle. Book excerpt: This book is the most comprehensive introductory text on the chemistry and biochemistry of milk. It provides a comprehensive description of the principal constituents of milk (water, lipids, proteins, lactose, salts, vitamins, indigenous enzymes) and of the chemical aspects of cheese and fermented milks and of various dairy processing operations. It also covers heat-induced changes in milk, the use of exogenous enzymes in dairy processing, principal physical properties of milk, bioactive compounds in milk and comparison of milk of different species. This book is designed to meet the needs of senior students and dairy scientists in general.

Download or read book Fractionation of Skim Milk by Microfiltration written by Veronica Mascarúa-Galindo and published by . This book was released on 1994 with total page 220 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Emerging Dairy Processing Technologies written by Nivedita Datta and published by John Wiley & Sons. This book was released on 2015-06-22 with total page 361 pages. Available in PDF, EPUB and Kindle. Book excerpt: Fluid milk processing is energy intensive, with high financial and energy costs found all along the production line and supply chain. Worldwide, the dairy industry has set a goal of reducing GHG emissions and other environmental impacts associated with milk processing. Although the major GHG emissions associated with milk production occur on the farm, most energy usage associated with milk processing occurs at the milk processing plant and afterwards, during refrigerated storage (a key requirement for the transportation, retail and consumption of most milk products). Sustainable alternatives and designs for the dairy processing plants of the future are now being actively sought by the global dairy industry, as it seeks to improve efficiency, reduce costs, and comply with its corporate social responsibilities. Emerging Dairy Processing Technologies: Opportunities for the Dairy Industry presents the state of the art research and technologies that have been proposed as sustainable replacements for high temperature-short time (HTST) and ultra-high temperature (UHT) pasteurization, with potentially lower energy usage and greenhouse gas emissions. These technologies include pulsed electric fields, high hydrostatic pressure, high pressure homogenization, ohmic and microwave heating, microfiltration, pulsed light, UV light processing, and carbon dioxide processing. The use of bacteriocins, which have the potential to improve the efficiency of the processing technologies, is discussed, and information on organic and pasture milk, which consumers perceive as sustainable alternatives to conventional milk, is also provided. This book brings together all the available information on alternative milk processing techniques and their impact on the physical and functional properties of milk, written by researchers who have developed a body of work in each of the technologies. This book is aimed at dairy scientists and technologists who may be working in dairy companies or academia. It will also be highly relevant to food processing experts working with dairy ingredients, as well as university departments, research centres and graduate students.

Download or read book Examination of Methods to Reduce Membrane Fouling During Dairy Microfiltration and Ultrafiltration written by Michael Corey Adams and published by . This book was released on 2012 with total page 137 pages. Available in PDF, EPUB and Kindle. Book excerpt: Pressure-driven membrane filtration processes such as microfiltration (MF), ultrafiltration (UF), nanofiltration (NF), and reverse osmosis (RO) provide opportunities for the dairy industry to better utilize milk by separating its components based on size. However, widespread adoption of some of these processes has yet to be realized due to membrane fouling. Membrane fouling is the accumulation of soil, or foulant, on the surface or within the pores of a membrane. Fouling prolongs processing times, increases energy and cleaning costs, decreases separation efficiency, and, in severe cases, may lead to irreversible clogging of the membrane. Microfiltration can be used to remove serum proteins (SP) from skim milk. The process' SP removal efficiency directly influences the technology's financial feasibility. Our first objective was to quantify the capacity of 0.14 [MICRO SIGN]m ceramic Isoflux MF membranes to remove SP from skim milk. The Isoflux membranes' manufacturer claims that using these membranes will reduce localized membrane fouling at the inlet end of the membrane that results from using high cross-flow velocities (5 - 7 m/s) to mitigate overall membrane fouling. Contrary to theoretical cumulative SP removal percentages of 68%, 90%, and 97% after 1, 2, and 3 stages of 3X MF processing, respectively, the 3X Isoflux process removed only 39.5%, 58.4%, and 70.2% after 1, 2, and 3 stages, respectively. Several design aspects of the membrane are thought to have resulted in this inefficiency. Ultrafiltration can be used to concentrate SP and reduce the lactose content of cheese whey or MF permeate of skim milk to produce 80% whey protein concentrates (WPC80) or 80% serum protein concentrates (SPC80), respectively. The objectives of our second study were to determine if adding annatto color to milk or bleaching whey or MF permeate of skim milk with hydrogen peroxide (H2O2) or benzoyl peroxide (BPO) influenced UF flux, diafiltration flux, or membrane fouling during production of WPC80 or SPC80. Addition of annatto color to milk had no effect on flux or fouling. Bleaching with or without added color increased flux during processing. Bleaching with H2O2 produced higher flux than bleaching with BPO. While bleaching with BPO reduced membrane fouling during WPC80 production, it did not impact membrane fouling during SPC80 production. Bleaching with H2O2 led to the largest reduction in fouling for both production processes.

Download or read book Alternatives to Conventional Food Processing 2nd Edition written by Andrew Proctor and published by Royal Society of Chemistry. This book was released on 2018-01-17 with total page 528 pages. Available in PDF, EPUB and Kindle. Book excerpt: This updated edition provides a review of the current major technologies that reduce energy cost and reduce environmental impact while maintaining food safety and quality.

Download or read book The Sensory Evaluation of Dairy Products written by Stephanie Clark and published by Springer Science & Business Media. This book was released on 2009-07-30 with total page 576 pages. Available in PDF, EPUB and Kindle. Book excerpt: The Sensory Evaluation of Dairy Products, Second Edition is for all who seek a book entirely devoted to sensory evaluation of dairy products and modern applications of the science. It is an excellent scientific reference for training in dairy product evaluation and is a practical guide to the preparation of samples for sensory evaluation. The book contains updates of the original text of the well-received first edition, as well as brand new material. This unique book is designed for professionals involved in many aspects of dairy production, including academic teaching and research, processing, quality assurance, product development and marketing. It is an invaluable tool for those who compete in the annual Collegiate Dairy Product Evaluation Contest.

Download or read book Biofilms in the Dairy Industry written by Koon Hoong Teh and published by John Wiley & Sons. This book was released on 2015-08-31 with total page 292 pages. Available in PDF, EPUB and Kindle. Book excerpt: In recent years, the formation and impacts of biofilms on dairy manufacturing have been studied extensively, from the effects of microbial enzymes produced during transportation of raw milk to the mechanisms of biofilm formation by thermophilic spore-forming bacteria. The dairy industry now has a better understanding of biofilms and of approaches that may be adopted to reduce the impacts that biofilms have on manufacturing efficiencies and the quality of dairy products. Biofilms in the Dairy Industry provides a comprehensive overview of biofilm-related issues facing the dairy sector. The book is a cornerstone for a better understanding of the current science and of ways to reduce the occurrence of biofilms associated with dairy manufacturing. The introductory section covers the definition and basic concepts of biofilm formation and development, and provides an overview of problems caused by the occurrence of biofilms along the dairy manufacturing chain. The second section of the book focuses on specific biofilm-related issues, including the quality of raw milk influenced by biofilms, biofilm formation by thermoduric streptococci and thermophilic spore-forming bacteria in dairy manufacturing plants, the presence of pathogens in biofilms, and biofilms associated with dairy waste effluent. The final section of the book looks at the application of modelling approaches to control biofilms. Potential solutions for reducing contamination throughout the dairy manufacturing chain are also presented. Essential to professionals in the global dairy sector, Biofilms in the Dairy Industry will be of great interest to anyone in the food and beverage, academic and government sectors. This text is specifically targeted at dairy professionals who aim to improve the quality and consistency of dairy products and improve the efficiency of dairy product manufacture through optimizing the use of dairy manufacturing plant and reducing operating costs.

Download or read book Membrane Processing written by Adnan Y. Tamime and published by John Wiley & Sons. This book was released on 2013-02-18 with total page 389 pages. Available in PDF, EPUB and Kindle. Book excerpt: This book extensively reviews the dairy, beverage and distilled spirits applications of membrane processing techniques. The four main techniques of membrane filtration are covered: microfiltration, ultrafiltration, nanofiltration and reverse osmosis. The book is divided into four informal sections. The first part provides an overview of membrane technology, including the main scientific principles; the major membrane types and their construction; cleaning and disinfection; and historical development. The second part focuses on dairy applications including liquid and fermented milks; cheese; whey; and milk concentrates. The third part of the book addresses beverage applications including mineral waters, fruit juices and sports drinks, and the final part looks at membrane filtration in the production of beers, wines and spirits.

Download or read book Membranes for Food Applications written by Klaus-Viktor Peinemann and published by John Wiley & Sons. This book was released on 2011-08-04 with total page 266 pages. Available in PDF, EPUB and Kindle. Book excerpt: Edited by an internationally recognized leader in the field, this third volume in the series represents the complete reference to membrane processes in the food industry. The handbook adopts a highly practical approach to this hot topic, combining the hands-on experience of the expert authors involved. They provide chapters devoted to such varied applications as dairy fractionation, electrodialysis, pressure-driven membrane processes in alcoholic beverages, membrane emulsification, contactors and bioreactors, as well as membranes for food packaging.

Download or read book Ultrafiltration and Microfiltration Handbook written by Munir Cheryan and published by CRC Press. This book was released on 1998-01-26 with total page 549 pages. Available in PDF, EPUB and Kindle. Book excerpt: Soon after its publication in 1987, the first edition of Ultrafiltration Handbook became recognized as the leading handbook on ultrafiltration technology. Reviews in professional journals praised it as an authoritative and substantive information resource on this technology. Now a completely, updated and expanded edition is available under the titl

Download or read book The Study of Membrane Fouling During Ultrafiltration of Milk written by Susan Clarke Gettys Larson and published by . This book was released on 1989 with total page 456 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Advanced Dairy Chemistry written by Paul L. H. McSweeney and published by Springer Science & Business Media. This book was released on 2009-04-20 with total page 794 pages. Available in PDF, EPUB and Kindle. Book excerpt: The Advanced Dairy Chemistry series was first published in four volumes in the 1980s (under the title Developments in Dairy Chemistry) and revised in three volumes in the 1990s. The series is the leading reference source on dairy chemistry, providing in-depth coverage of milk proteins, lipids, lactose, water and minor constituents. Advanced Dairy Chemistry Volume 3: Lactose, Water, Salts, and Minor Constituents, Third Edition, reviews the extensive literature on lactose and its significance in milk products. This volume also reviews the literature on milk salts, vitamins, milk flavors and off-flavors and the behaviour of water in dairy products. Most topics covered in the second edition are retained in the current edition, which has been updated and expanded considerably. New chapters cover chemically and enzymatically prepared derivatives of lactose and oligosaccharides indigenous to milk. P.L.H. McSweeney Ph.D. is Associate Professor of Food Chemistry and P.F. Fox Ph.D., D.Sc. is Professor Emeritus of Food Chemistry at University College, Cork, Ireland.

Download or read book Microfiltration and Ultrafiltration written by Zeman and published by Routledge. This book was released on 2017-11-22 with total page 654 pages. Available in PDF, EPUB and Kindle. Book excerpt: Integrates knowledge on microfiltration and ultrification, membrane chemistry, and characterization methods with the engineering and economic aspects of device performance, device and module design, processes, and applications. The text provides a discussion of membrane fundamentals and an analytical framework for designing and developing new filtrations systems for a broad range of technologically important functions. It offers information on membrane liquid precursors, fractal and stochastic pore space analysis, novel and advanced module designs, and original process design calculations.

Download or read book Standard Methods for the Examination of Dairy Products written by H. Michael Wehr and published by Ignatius Press. This book was released on 2004 with total page 592 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Food Process Engineering and Technology written by Zeki Berk and published by Academic Press. This book was released on 2013-06-08 with total page 721 pages. Available in PDF, EPUB and Kindle. Book excerpt: The past 30 years have seen the establishment of food engineering both as an academic discipline and as a profession. Combining scientific depth with practical usefulness, this book serves as a tool for graduate students as well as practicing food engineers, technologists and researchers looking for the latest information on transformation and preservation processes as well as process control and plant hygiene topics. - Strong emphasis on the relationship between engineering and product quality/safety - Links theory and practice - Considers topics in light of factors such as cost and environmental issues