Download or read book Field Performance of Epoxy coated Reinforcing Steel in Virginia Bridge Decks written by W. Pyc and published by . This book was released on 2000 with total page 4 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Field Performance of Epoxy coated Reinforcing Steel in Virginia Bridge Decks written by and published by . This book was released on 2000 with total page 38 pages. Available in PDF, EPUB and Kindle. Book excerpt: In this study, the corrosion protection performance of epoxy-coated reinforcing steel (ECR) was evaluated using approximately 250 concrete cores from 18 bridge decks in Virginia. The decks were 2 to 20 years old at the time of the investigation. The deck field inspections included a crack survey and cover depth determination in the right traffic lane. A maximum of 12 cores with the top reinforcement randomly located in the lowest 12th percentile cover depth were taken from each bridge deck. Because of the safety concerns associated with taking cores from the lower steel mat, and to minimize damage to the bridge, a maximum of only 3 cores were taken through the truss bars. The laboratory evaluation of the concrete cores included a visual examination and a determination of the carbonation depth, moisture content, absorption, percent saturation, and chloride content at a 13-mm depth. The rapid chloride permeability test was also performed for the surface and base concrete on samples obtained from the cores taken through the truss bars to determine chloride permeability. The ECR inspection consisted of a visual examination, a damage evaluation, and a determination of coating thickness and adhesion. The condition of the steel underneath the epoxy coating was also evaluated. Adhesion loss of the epoxy coating to the steel surface was detected in all but one deck that was 4 years old and older. The epoxy coatings were debonding from the reinforcing bars. Whereas a bonded coating can be expected to protect the steel, a debonded coating allows chlorides, moisture, and oxygen to reach the steel and initiate a rapid corrosion mechanism. Reinforcing bars in various stages of adhesion loss showed visible signs of a corrosion process underneath the coating, suggesting that ECR will provide little or no additional service life for concrete bridge decks in comparison to bare steel. Other systems that will provide longer protection against chloride-induced corrosion of the reinforcing steel with a higher degree of reliability should be considered.

Download or read book Summary Report on the Performance of Epoxy coated Reinforcing Steel in Virginia written by Richard E. Weyers and published by . This book was released on 2006 with total page 32 pages. Available in PDF, EPUB and Kindle. Book excerpt: From 1992 to 2006, the Virginia Transportation Research Council and its contract researchers conducted a long-term systematic series of investigations to evaluate the corrosion protection effectiveness of epoxy-coated reinforcement (ECR) and to identify and recommend the best and most cost-effective corrosion protection system for Virginia bridge decks. This report summarizes this research and subsequent efforts to implement alternative reinforcement. The work was conducted, and is reported, in this general order: review of historical performance of ECR, ECR performance in solutions and concrete, and preliminary field investigations; investigation of field performance of bridge decks built with ECR; assessment of alternative corrosion protection methods; development of probabilistic service life models for bridge decks and laboratory assessment of ECR cores extracted from bridge decks to determine service life extension; efforts to implement alternative reinforcement. The series of studies demonstrated that the epoxy coating on ECR naturally degrades in the highly alkaline moist environment within concrete. The subsequent loss of bond, coupled with the inevitable flaws in the coating induced by construction, leads to an estimated service life benefit of ECR of as little as 3 to 5 years. Further, non-critical decks, beams, and substructure elements not exposed to marine environments, particularly on secondary and rural routes, can be cost-effectively constructed and maintained using low-permeability concrete and black reinforcing bar. However, because the Federal Highway Administration requires the use of corrosion-resistant reinforcement, and because ECR cannot provide adequate corrosion protection for structures designed for a 100-year+ service life as currently recommended by FHWA, the report recommends that the Virginia Department of Transportation amend its specifications regarding the use of ECR to require the use of corrosion-resistant metallic reinforcing bars such as MMFX2, stainless steel clad, and solid stainless steel.

Download or read book Field Investigation of the Corrosion Protection Performance of Bridge Decks and Piles Constructed with Epoxy coated Reinforcing Steel in Virginia written by and published by . This book was released on 1997 with total page 37 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Performance of Epoxy coated Reinforcing Steel in Highway Bridges written by Kenneth C. Clear and published by Transportation Research Board. This book was released on 1995 with total page 164 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Service Life Extension of Virginia Bridge Decks Afforded by Epoxy Coated Reinforcement written by MC. Brown and published by . This book was released on 2006 with total page 13 pages. Available in PDF, EPUB and Kindle. Book excerpt: A study was conducted on concrete core samples each containing a single top-mat reinforcing steel bar from ten bridge decks in Virginia. Two of the bridges contained conventional, uncoated mild reinforcing steel (Bare), and eight of the bridges were constructed with epoxy-coated reinforcement (ECR). The bridges ranged in age from 4 to 18 years, and were built under same specifications for concrete water-to-cement ratio (w/c) and cover depth. In the laboratory, the subject cores were prepared and corrosion activity was monitored via electrochemical impedance spectroscopy while subject to cyclic ponding of a 3 % NaCl solution over a 22-month exposure period. The relative corrosion performance of the Bare and ECR bars were evaluated, by comparison of the time to corrosion initiation and time to failure, as designated by visible cracking of the concrete cover. A stochastic model was employed, using bootstrap resampling techniques, to project the corrosion protection service life extension provided by epoxy-coated reinforcement as compared to Bare steel for the population of Virginia bridge decks. Less than 25 % of all Virginia bridge decks built under specifications in place since 1981 were projected to corrode sufficiently to require rehabilitation within 100 years, regardless of bar type. The corrosion service life extension attributable to ECR in bridge decks was found to be approximately 5 years beyond that of Bare steel.

Download or read book Corrosion Protection Service Life of Epoxy coated Reinforcing Steel in Virginia Bridge Decks written by Michael Carey Brown and published by . This book was released on 2003 with total page 63 pages. Available in PDF, EPUB and Kindle. Book excerpt: The corrosion protection service life extension provided by epoxy-coated reinforcement (ECR) was determined by comparing ECR and bare steel bars from 10 Virginia bridge decks built between 1981 and 1995. The objective was to determine the corrosion protection service life time extension provided by ECR field specimens with various degrees of coating adhesion: disbonded, partially disbonded, and wholly bonded coatings. The size and length distributions of cracks in Virginia bridge decks were investigated to assess the frequency and severity of cracks. Correlation of cracks with chloride penetration was used to characterize the influence of cracking on deck deterioration. Cracks influence the rate of chloride penetration, but the frequency and width distributions of cracks indicate that cracks are not likely to shorten the overall service life of most bridge decks in Virginia. Altogether, 141 drilled cores, 102 mm (4 inches) in diameter, were employed in this study. For each of the decks built with ECR, 10 to 12 cores were drilled through a top reinforcing bar adjacent to the previous study core locations. In addition, approximately 3 cores were drilled through a top reinforcing bar at a surface crack location. Laboratory testing involved nondestructive monitoring using advanced electrochemical techniques to periodically assess the corrosion state of the steel bars during cyclic exposure to chloride-rich solution over 36 months of treatment. Time of corrosion initiation and time of cracking (where applicable), as well as chloride content of the concrete before and after treatment, were used in the analysis. Analysis of the epoxy coating after treatment showed the presence of micro cracks in the surface of some coatings, and moisture uptake and glass transition temperatures, as related to curing of the coatings, were investigated. Less than 25 percent of all Virginia bridge decks built under specifications in place since 1981 is projected to corrode sufficiently to require rehabilitation within 100 years, regardless of bar type. The corrosion service life extension attributable to ECR in bridge decks was found to be approximately 5 years beyond that of bare steel and, therefore, ECR is not a cost-effective method of corrosion prevention for bridge decks. Deleting the requirement for ECR in decks would save Virginia approximately $845,000 per year.

Download or read book Performance of Epoxy Coated Rebars in Bridge Decks written by J. L. Smith and published by . This book was released on 1996 with total page 100 pages. Available in PDF, EPUB and Kindle. Book excerpt: Epoxy coated rebar (ECR) was introduced in the mid 1970s as a means to minimize concrete deterioration caused by corrosion of the reinforcing steel and to extend the useful life of highway structures. This report summarizes the results of investigations performed by highway agencies in the United States and Canada, academia, and the Canadian Strategic Highway Research Program to evaluate the performance of ECR. A total of 92 bridge decks, two bridge barrier rails, and one noise barrier rail was evaluated in the States of California, Indiana, Kansas, Michigan, Minnesota, New York, Ohio, Pennsylvania, Virginia, West Virginia, and Wisconsin, and the provinces of Alberta, Nova Scotia, and Ontario.

Download or read book Concrete Bridge Deck Performance written by H. G. Russell and published by Transportation Research Board. This book was released on 2004 with total page 188 pages. Available in PDF, EPUB and Kindle. Book excerpt: At head of title: National Cooperative Highway Research Program.

Download or read book Advanced Concretes and Their Structural Applications written by Zhigang Zhang and published by Frontiers Media SA. This book was released on 2022-09-23 with total page 303 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Epoxy coated Reinforcement written by Jerzy Zemajtis and published by . This book was released on 1996 with total page 104 pages. Available in PDF, EPUB and Kindle. Book excerpt: This report is a historical performance review of epoxy-coated reinforcement. The information in this report is presented in chronological order starting from the early 1970's, when the first bridge with epoxy-coated reinforcement was built, and ending with the presentation at the 1993 TRB sessions, where findings from the latest research investigations were revealed. The report includes background information on fundamental applications of epoxy-coated reinforcing steel. Major laboratory studies, which addressed corrosion resistance and bond strength issues, are presented. Field investigations of meaningful structures with successful application of epoxy -coated reinforcing steel as well as structures with total failure of epoxy-coated reinforcement are also presented. The report also includes transcripted presentations, from the 1993 TRB sessions, which addressed quality control, adhesion characteristics, and other factors associated with long-term performance of epoxy-coated reinforcing steel. Conclusions from the laboratory and field investigations, as well as from the presentations of 1993 TRB sessions are presented.

Download or read book Nationally Coordinated Program of Highway Research Development and Technology Annual Progress Report Fiscal Year 1994 written by and published by . This book was released on 1995 with total page 168 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Methods of Corrosion Protection and Durability of Concrete Bridge Decks Reinforced with Epoxy coated Bars Phase I written by Lisa M. Samples and published by . This book was released on 1999 with total page 276 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book PRO 14 International RILEM CIB ISO Symposium on Integrated Life Cycle Design of Materials and Structures ILCDES 2000 written by Asko Sarja and published by RILEM Publications. This book was released on 2000 with total page 584 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Corrosion of Steel in Concrete Structures written by Amir Poursaee and published by Woodhead Publishing. This book was released on 2023-02-20 with total page 400 pages. Available in PDF, EPUB and Kindle. Book excerpt: Essential reading for researchers, practitioners, and engineers, this book covers not only all the important aspects in the field of corrosion of steel reinforced concrete but also discusses new topics and future trends. Theoretical concepts of corrosion of steel in concrete structures, the variety of reinforcing materials and concrete, including stainless steel and galvanized steel, measurements and evaluations, such as electrochemical techniques and acoustic emission, protection and maintenance methods, and modelling, latest developments, and future trends in the field are discussed. Comprehensive coverage of the corrosion of steel bars in concrete, investigating the range of reinforcing materials, and types of concrete Introduces the latest measuring methods, data collection, and advanced modeling techniques Second edition covers a range of new, emerging topics such as the concept of chloride threshold value, concrete permeability and chloride diffusion, the role of steel microstructure, and innovations in corrosion detection devices

Download or read book Public Roads written by and published by . This book was released on 1999 with total page 392 pages. Available in PDF, EPUB and Kindle. Book excerpt:

Download or read book Evaluation of Epoxy Coated Reinforcing Steel in Bridge Decks written by Satinder K. Munjal and published by . This book was released on 1981 with total page 131 pages. Available in PDF, EPUB and Kindle. Book excerpt: