Download or read book Evaluation of Long term Field Performance of Cold In place Recycled Roads written by and published by . This book was released on 2007 with total page 40 pages. Available in PDF, EPUB and Kindle. Book excerpt: Cold in-place recycling (CIR) has become an attractive method for rehabilitating asphalt roads that have good subgrade support and are suffering distress related to non-structural aging and cracking of the pavement layer. Although CIR is widely used, its use could be expanded if its performance were more predictable. Transportation officials have observed roads that were recycled under similar circumstances perform very differently for no clear reason. Moreover, a rational mix design has not yet been developed, design assumptions regarding the structural support of the CIR layer remain empirical and conservative, and there is no clear understanding of the cause-effect relationships between the choices made during the design/construction process and the resulting performance. The objective of this project is to investigate these relationships, especially concerning the age of the recycled pavement, cumulative traffic volume, support conditions, aged engineering properties of the CIR materials, and road performance. Twenty-four CIR asphalt roads constructed in Iowa from 1986 to 2004 were studied: 18 were selected from a sample of roads studied in a previous research project (HR-392), and 6 were selected from newer CIR projects constructed after 1999. This report summarizes the results of a comprehensive program of field distress surveys, field testing, and laboratory testing for these CIR asphalt roads. The results of this research can help identify changes that should be made with regard to design, material selection, and construction in order to lengthen the time between rehabilitation cycles and improve the performance and cost-effectiveness of future recycled roads.
Download or read book Evaluation of Long term Field Performance of Cold In place Recycled Roads written by Hosin David Lee and published by . This book was released on 2007 with total page 110 pages. Available in PDF, EPUB and Kindle. Book excerpt: Cold in-place recycling (CIR) has become an attractive method for rehabilitating asphalt roads that have good subgrade support and are suffering distress related to non-structural aging and cracking of the pavement layer. Although CIR is widely used, its use could be expanded if its performance were more predictable. Transportation officials have observed roads that were recycled under similar circumstances perform very differently for no clear reason. Moreover, a rational mix design has not yet been developed, design assumptions regarding the structural support of the CIR layer remain empirical and conservative, and there is no clear understanding of the cause-effect relationships between the choices made during the design/construction process and the resulting performance. The objective of this project is to investigate these relationships, especially concerning the age of the recycled pavement, cumulative traffic volume, support conditions, aged engineering properties of the CIR materials, and road performance. Twenty-four CIR asphalt roads constructed in Iowa from 1986 to 2004 were studied: 18 were selected from a sample of roads studied in a previous research project (HR-392), and 6 were selected from newer CIR projects constructed after 1999. This report describes the results of field distress surveys conducted on these CIR asphalt roads. The results indicate that the CIR roads performed better than expected, and the service life estimate has therefore been changed from 18 to 25 years. Moreover, the predicted service life of the roads with good subgrade support was much longer than that of the roads with poor subgrade support. The results of this research can help identify changes that should be made with regard to design, material selection, and construction in order to improve the performance and cost-effectiveness of future recycled roads.
Download or read book Evaluation of Long term Performance of Cold In place Recycled Asphalt Roads written by Dong Chen and published by . This book was released on 2006 with total page 526 pages. Available in PDF, EPUB and Kindle. Book excerpt: Asphalt pavements deteriorate over time. Typically three to five years following construction, reflected cracks, one of the primary forms of distress in hot-mix asphalt overlays of flexible pavements, may be observed. When rolled down, reflected cracks affect ride quality. In addition, reflected cracks allow the penetration of water into the pavement and the base. The water causes the asphalt mix to deteriorate and the base to soften. Consequently the service life of pavements is reduced. Cold In-Place Recycling (CIR) provides an economical rehabilitation method that mitigates crack reflection by pulverizing the asphalt pavement surface, thus destroying the old crack pattern in the recycled layer. However, recycled roads have inconsistent performance. Several years after recycling, some roads are still in excellent condition with only a few minor cracks while extensive cracking and rutting were observed on other roads. These opposite behaviors can be observed on roads that were constructed in the same county, by the same contractor in the same construction season. Thus the difference in performance is probably not from such factors as weather, equipment, contractors' experiences, and construction procedures. Rather, other factors become more prominent in affecting pavement performance, such as: age of the recycled pavement; traffic volume; support conditions; and aged engineering properties of the CIR materials. This dissertation investigates how aged engineering properties of the CIR materials and other factors affect pavement performance. Twenty-four sample roads were selected to represent various ages, traffic volumes, and support conditions in a geographically balanced sampling in Iowa. Pavement Condition Index (PCI) ratings were collected using an automated pavement distress digital image collection and analysis system. Engineering properties of CIR materials were examined through field and lab tests. Statistical analyses were conducted to descript the relationships between the pavement performance and the prominent factors. The conclusions and recommendations were presented in this dissertation.
Download or read book Comparing Cold In place Recycling CIR and Cold In place Recycling with Expanded Asphalt Mixture CIREAM written by Janki Bhavsar and published by . This book was released on 2015 with total page 134 pages. Available in PDF, EPUB and Kindle. Book excerpt: Cold Mix Asphalt (CMA) is used in several rehabilitation techniques, which uses 100% Reclaimed Asphalt Pavement (RAP), thus making it a sustainable product in the industry. Using CMA for rehabilitation decreases the energy consumption and greenhouse gas emissions. In Ontario, it has been implemented over the past 17 years. There are two main techniques used for CMA: Cold In-Place Recycling (CIR) and Cold In-Place Recycling with Expanded Asphalt Mixture (CIREAM). It is necessary to determine the performance of these techniques in order to determine the age of the pavement and expand their applications. There is a lack of laboratory and field performance information in Ontario for these two techniques. Thus, in this study, laboratory investigation was carried out to establish and compare the material performance of CIR and CIREAM. In addition, a field study was conducted which involved the evaluation of several road sections which have used CIR and CIREAM techniques. For this project, the test material was collected from road sections in Ontario, thus, this study was focused on CIR and CIREAM applications in Ontario and tests were based on standards followed by the province. Although the study was conducted for Ontario, the methodology may be applied outside of Ontario with similar climate conditions. However, the results would vary based on the type of material used. The laboratory study included testing for the overall stiffness, tensile strength, and fatigue behavior of the test samples to simulate their long-term performance. RAP was extracted from southern and northern parts of Ontario to make the test samples. A curing duration test was conducted using the dynamic modulus test apparatus. This test was done to determine a curing time of CIR samples in the laboratory which provided the best stiffness. For the stiffness test, sample mixes were constructed with varying percentages of asphalt cement (AC). From these mixes, the best performing mix was chosen based on its workability, rutting resistance and overall stiffness. The fatigue and tensile strength tests were conducted using the optimal mix chosen from the stiffness test and the samples were cured according to the results from the curing duration test. From the curing duration test, it was concluded that curing the CIR samples for 14 days after compaction gave a higher stiffness to the mix. For the CIR mixes using southern Ontario RAP, the mix with 3.2%AC performed well in comparison to the other mixes. The CIREAM mixes with varying percentages of AC had an overall similar performance. The fatigue testing showed that both CIR and CIREAM samples had similar fatigue resistance. The TSRST tests showed that CIR samples exhibited more shrinkage in comparison to CIREAM and they had higher tensile stresses at failure. The dynamic modulus testing of the CIR samples using northern Ontario RAP showed no statistically significant differences between the mixes. The gradation of the RAP used had a large impact on the stiffness and workability of the sample mixes and their performance. The field study included road sections with varying roadway and pavement attributes. Data was collected from various municipalities which included the City of Waterloo, County of Peterborough, Region of Northumberland, York Region, Haldimand County, County of Perth, County of Wellington, and the united counties of Stormont, Dundas and Glengarry, along with the Ministry of Transportation Ontario (MTO). This data highlighted the limits of all road sections which had implemented CIR or CIREAM within the municipalities. Approximately 200 road sections were identified which had used CIR or CIREAM techniques. These sections were visually inspected in three different municipalities; specifically the City of Waterloo, Perth County, and the united counties of Stormont, Dundas and Glengarry. From the visual inspections large amounts of deteriorations were observed where greater number of trucks, poor drainage and low speeds were prevalent. Field data evaluation showed no significant effect on physical condition, PCI or rut depth of the roadway due to age, AADT or AADTT, respectively. To date, these techniques are used on low volume roadways but there is also an opportunity to expand to higher volume roadways to promote sustainable use of recycled asphalt. These techniques are sustainable due to their use of 100% recycled aggregates and low energy consumption. Thus, by closing the research gap on their performance information, it would help broaden their application.
Download or read book Long Term Performance Evaluation of Cold In place Recycling CIR Technique in Nevada written by Selvaratnam Sanjeevan and published by . This book was released on 2013 with total page 1890 pages. Available in PDF, EPUB and Kindle. Book excerpt: Cold in-place recycling (CIR) is one of the commonly used rehabilitation technique for asphalt pavements in Nevada. Nevada Department of Transportation (NDOT) has long been using CMS-2S emulsion for CIR projects and recently has introduced Reflex emulsion and PASS emulsion for CIR. A difference in the performance of the CIR with changing emulsion technology has been observed which warranted the need for this study to assess the long-term performance of CIR pavements throughout Nevada. The long term performance of 67 CIR projects was evaluated in this study. The evaluated CIR projects were divided based on the rehabilitation type and then sub-divided based on the emulsion technology. Performances of the various projects were analyzed by individual distresses such as longitudinal cracking, fatigue cracking, transverse cracking, block cracking, roughness and rutting using NDOT's pavement management system data. In addition, overall condition of the pavement was evaluated using PCI values. A statistical approach called principal component analysis also used to evaluate the effectiveness of CIR in Nevada. The study revealed that CIR followed by a HMA overlay and a surface treatment performed much better on high volume roads than CIR with surface treatment on low volume roads. Transverse and longitudinal cracking were the two major types of distresses in CIR pavements. About 50% of the pavements constructed with HMA overlay and surface treatment and 95% of the pavements constructed with only surface treatment experienced transverse cracking during their service life. About 30% of the pavements constructed with HMA overlay and surface treatment and 70% of the pavements constructed with only surface treatment experienced longitudinal cracking. The CIR technology with HMA overlay and surface treatment significantly improved the rutting resistance and roughness of the pavement. The climatic condition, CIR layer thickness, and surface treatment types were not found to affect the performance of CIR roads. The CMS-2S projects without HMA overlay and 1.5 to 2.5 inches HMA overlay were predicted to reach a PCI value of 60 for rehabilitation 15 years after construction. The CMS-2S projects constructed with 3 to 4 inches of HMA overlay performed excellent up to 9 years and expected to last more than 20 years before rehabilitation. The CIR with CMS-2S and PASS emulsions constructed with surface treatment were predicted to reach a PCI level of 60 after 15 and 19 years, respectively. However, Reflex emulsion was predicted to be due for rehabilitation only after 6 years from construction.
Download or read book Evaluation of Cold In place Recycling written by Stephen Alan Cross and published by . This book was released on 1995 with total page 190 pages. Available in PDF, EPUB and Kindle. Book excerpt: Kansas has many miles of thermally cracked roads primarily in the western one-half of the State. Rehabilitation with conventional hot mix asphalt overlays and hot recycling have not given the service life expected before the existing cracks reflect through the pavement. Since 1986, the Kansas Department of Transportation has been utilizing cold in-place recycling (CIR) with an emulsified asphalt as an additive as a cost effective alternative for rehabilitation of thermally cracked low volume pavements. Field performance of the final product appears to have more variation than desirable with an expected life of three to five years. The results of a two year study indicate that the material properties of the locally available aggregates are poor which results in low strength of the CIR mixes. In addition, the in-place air voids of the wearing surface were high and had an adverse effect on the performance of CIR mixes.
Download or read book Superpave Mix Design written by Asphalt Institute and published by . This book was released on 2001-01-01 with total page 102 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Proceedings of the RILEM International Symposium on Bituminous Materials written by Hervé Di Benedetto and published by Springer Nature. This book was released on 2021-09-25 with total page 1806 pages. Available in PDF, EPUB and Kindle. Book excerpt: This volume highlights the latest advances, innovations, and applications in bituminous materials and structures and asphalt pavement technology, as presented by leading international researchers and engineers at the RILEM International Symposium on Bituminous Materials (ISBM), held in Lyon, France on December 14-16, 2020. The symposium represents a joint effort of three RILEM Technical Committees from Cluster F: 264-RAP “Asphalt Pavement Recycling”, 272-PIM “Phase and Interphase Behaviour of Bituminous Materials”, and 278-CHA “Crack-Healing of Asphalt Pavement Materials”. It covers a diverse range of topics concerning bituminous materials (bitumen, mastics, mixtures) and road, railway and airport pavement structures, including: recycling, phase and interphase behaviour, cracking and healing, modification and innovative materials, durability and environmental aspects, testing and modelling, multi-scale properties, surface characteristics, structure performance, modelling and design, non-destructive testing, back-analysis, and Life Cycle Assessment. The contributions, which were selected by means of a rigorous international peer-review process, present a wealth of exciting ideas that will open novel research directions and foster new multidisciplinary collaborations.
Download or read book Proceedings of the 7th International Conference on Geotechnics Civil Engineering and Structures CIGOS 2024 4 5 April Ho Chi Minh City Vietnam written by Cuong Ha-Minh and published by Springer Nature. This book was released on with total page 1604 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Evaluation of Long Term Behavior of Cold recycled Asphalt Pavement Using the Creep Test written by Nicolas Faouzi Ayoub and published by . This book was released on 1983 with total page 158 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Asphalt Cold Mix Manual written by Asphalt Institute and published by . This book was released on 2001-01-01 with total page 185 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Eco efficient Pavement Construction Materials written by Fernando Pacheco-Torgal and published by Woodhead Publishing. This book was released on 2020-01-18 with total page 422 pages. Available in PDF, EPUB and Kindle. Book excerpt: Eco-efficient Pavement Construction Materials acquaints engineers with research findings on new eco-efficient pavement materials and how they can be incorporated into future pavements. Divided into three distinctive parts, the book emphasizes current research topics such as pavements with recycled waste, pavements for climate change mitigation, self-healing pavements, and pavements with energy harvesting potential. Part One considers techniques for recycling, Part Two reviews the contribution of pavements for climate change mitigation, including cool pavements, the development of new coatings for high albedo targets, and the design of pervious pavements. Finally, Part Three focuses on self-healing pavements, addressing novel materials and design and performance. Finally, the book discusses the case of pavements with energy harvesting potential, addressing different technologies on this field. Offers a clear and concise lifecycle assessment of asphalt pavement recycling for greenhouse gas emission with temporal aspects Applies key research trends to green the pavement industry Includes techniques for recycling waste materials, the design of cool pavements, self-healing mechanisms, and key steps in energy harvesting
Download or read book Performance Evaluation of Cold In place Recycling Projects in Arizona written by J. Mallela and published by . This book was released on 2006 with total page 138 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book In depth Study of Cold In place Recycled Pavement Performance Construction and inspection manual written by Todd V. Scholz and published by . This book was released on 1990 with total page 58 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Federally Coordinated Program of Research and Development in Highway Transportation written by and published by . This book was released on 1982 with total page 688 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book In depth Study of Cold In place Recycled Pavement Performance Final report written by Todd V. Scholz and published by . This book was released on 1990 with total page 230 pages. Available in PDF, EPUB and Kindle. Book excerpt:
Download or read book Annual Report of Iowa Highway Research Board Research and Development Activities for the Fiscal Year Ending written by Iowa. Highway Research Board and published by . This book was released on 2008 with total page 106 pages. Available in PDF, EPUB and Kindle. Book excerpt: